铁屑微电解法处理电解锰生产废水

journal6 ›› 2002, Vol. 23 ›› Issue (2): 34-37.

铁屑微电解法处理电解锰生产废水

（1.吉首大学化学系，湖南吉首 416000；2.湘西自治州环保所，湖南吉首 416000）

出版日期:2002-06-15 发布日期:2013-01-05
作者简介:欧阳玉祝(1956-)，男，湖南省永州市人，吉首大学化学系副教授，主要从事机械化工和环境工程学研究.

Treatment of the Electrolytic Mangan Wastewater byIron Chipping Microelectrolysis

(1.Department of Chemistry，Jishou University, Jishou 416000，Hunan China；2.Research Institute of Environmental Protection of Xiangxi,Jishou 416000，Hunan China)

Online:2002-06-15 Published:2013-01-05

摘要/Abstract

摘要：用废铁屑为原料对电解锰生产废水进行处理，考察了铁屑用量、反应时间和废水pH值对Cr⁶⁺，Mn²⁺去除率的影响.实验结果表明，在铁屑用量为15%，废水pH值为4，常温下反应120 min的条件下，Cr⁶⁺，Mn²⁺的去除率在99.7%以上，总铬去除率达99.2%.同时，将实验结果用于工厂废水处理运行，效果良好，Cr⁶⁺的去除率为99.45%，Mn²⁺的去除率为95.53%.

关键词： 铁屑, 微电解, 废水

Abstract: The electrolytic mangan wastewater was processed by iron chipping.The factors of iron chipping amount, reaction time and the influence of wastewater pH on the purgation ratio of Cr⁶⁺,Mn²⁺ were investigated. The results show that under usual temperature when amount of iron chipping is 15%, wastewater pH is 4.00, reaction time is 120 min, Cr⁶⁺,Mn²⁺ and total chromium purgation ratio were 99.7% and 99.2%.when it was used to practice the treatment electrolytic mangan wastewater, purgation ratio of Cr⁶⁺,Mn²⁺ was 99.45% and 95.53%.

Key words: iron chipping, microelectrolysis, wastewater

欧阳玉祝, 沈扬, 李清平, 李建华, 许景明. 铁屑微电解法处理电解锰生产废水[J]. journal6, 2002, 23(2): 34-37.

OuYang-Yu-Zhu , SHEN Yang, LI Qing-Ping, LI Jian-Hua, XU Jing-Ming. Treatment of the Electrolytic Mangan Wastewater byIron Chipping Microelectrolysis[J]. journal6, 2002, 23(2): 34-37.

[1]	龙秋萍，杨宁，聂倩雯，王亚光，何则强. 香烟过滤嘴烧结碳材料对亚甲基蓝的吸附性能[J]. 吉首大学学报（自然科学版）, 2017, 38(1): 70-74.
[2]	吕星浩. 铁碳微电解处理废水中的镉/锌/铅[J]. journal6, 2015, 36(3): 73-76.
[3]	李传常, 唐爱东. 处理高炉煤气洗涤废水的工业试验[J]. journal6, 2013, 34(1): 77-81.
[4]	曹建兵, 李小明, 欧阳玉祝, 郑伟, 王东波. 耐锰活体霉菌Fusarium sp.处理含锰废水[J]. journal6, 2011, 32(3): 96-99.
[5]	石美莲, 段友构, 颜文斌, 任从莲. V (Ⅴ)-KIO₄-甲基红体系动力学光度法测定微量钒[J]. journal6, 2010, 31(2): 94-96.
[6]	何德文. 超滤膜间歇处理处理含油废水的实验效果[J]. journal6, 2005, 26(4): 21-25.
[7]	鲁秀国, 梁淑轩, 于泊蕖. TiO₂复合吸附剂处理六价铬废水[J]. journal6, 2002, 23(2): 15-18.
[8]	彭清静, 王继徽, 赵欣, 甘海明. 黄磷废水的二氧化氯处理[J]. journal6, 2002, 23(1): 77-79.
[9]	傅伟昌, 王继徽. 改性天然高分子重金属离子去除剂的研究现状[J]. journal6, 2001, 22(3): 86-89.