从无铁渣湿法炼锌流程还原补锰液中萃取铟

吉首大学学报（自然科学版） ›› 2004, Vol. 25 ›› Issue (4): 14-18.

从无铁渣湿法炼锌流程还原补锰液中萃取铟

（中南大学冶金科学与工程学院，湖南长沙 410083）

出版日期:2004-12-15 发布日期:2012-09-22
作者简介:李仕庆（1958-）,男,中南大学博士,高级工程师,主要从事锡、锑、铅、锌等有色金属冶金的研究.
基金资助:
国家自然科学基金资助项目（50234010）

Extracting Indium From Reduced Solution With Adding Manganese in the Hydrometallurgy of Zinc Without Producing Iron Residue

(College of Metallurgical Science and Engineering,Central South University,Changsha 410083,China)

Online:2004-12-15 Published:2012-09-22

摘要/Abstract

摘要：考察了P₂0₄对Fe²⁺，Mn²⁺，Zn²⁺及In³⁺的硫酸盐模拟溶液中各种金属离子的萃取性能，然后对真实溶液无铁渣湿法炼锌流程中高酸浸出液的还原补锰液中的铟进行萃取分离.确定了萃取分离铟的最佳条件为：(ⅰ)有机相组成分为30%P₂0₄+70%磺化煤油；（ⅱ）温度20　℃±；（ⅲ）级数3级；（ⅳ）相比O/A=3∶1；（ⅴ）时间5　min，在最佳条件下，铟的萃取率≥99.4%，P204对In³⁺，Zn²⁺，Mn2⁺　３种金属的萃取饱和容量分别为54.0　g·L^-1，22.0　g·L^-1和2.0　g·L^-1，全流程铟的直收率达到77.58%，总回收率≥95.0%，比传统提取铟流程回收率提高20%以上.

关键词： 铟, 萃取, 湿法炼锌, 无铁渣

Abstract: The extraction of the cations such as Fe²⁺,Mn²⁺,Zn²⁺and In³⁺ in the simulated sulfate solution by P₂04 has been examined from a technology solution-reduction solution with adding manganese,that was obtained by reduction of the high leached solution in the hydrometallurgy of zinc without iron residue.The optimum separation conditions have been determined as:(1) component of the organic phase being 30% kerosene+ 70% sulfidized kerosene,(2) extraction temperature being 20 ℃,（3）progressions being 3,(4) ratio of O/A being 3∶1,and (5) extration time being 5 min.Under the optimum extraction conditions,the extration rate of indium is not less than 99.4%.the saturated capacities of P₂0₄ on In³⁺,Zn²⁺ and Mn²⁺were measured for 54.0 mg·mL^-1，22.0　mg·mL^-1　and 2.0　mg·mL^-1respectively.The direct recovery rate of indium for the whole flow sheet arrived at 77.58% and the total recovery rate reached 95.0%,In comparision with the traditional flow sheet the total recovery rate of indium was higher than 20%.

Key words: indium, etraction, hydrometallurgy of Zinc, without iron residue

李仕庆, 刘伟锋, 唐谟堂, 何静, 鲁君乐 . 从无铁渣湿法炼锌流程还原补锰液中萃取铟[J]. 吉首大学学报（自然科学版）, 2004, 25(4): 14-18.

LI Shi-Qing, LIU Wei-Feng, TANG Mo-Tang, HE Jing, LU Jun-Le- . Extracting Indium From Reduced Solution With Adding Manganese in the Hydrometallurgy of Zinc Without Producing Iron Residue[J]. Journal of Jishou University(Natural Sciences Edition), 2004, 25(4): 14-18.

[1]	饶青青. 气质联用法测定湘西香醋中7种挥发性成分[J]. 吉首大学学报（自然科学版）, 2024, 45(1): 61-65.
[2]	戴冬阳,刘志雄,孙琳,汤连东,邹晓勇. 萃取法脱除工业级硫酸锰溶液中钙和镁离子[J]. 吉首大学学报（自然科学版）, 2016, 37(5): 55-58.
[3]	张树贵, 孙赛兰, 董红敏, 王鹏鹏, 李佑稷, 覃事栋. 异丙醇-硫酸铵-PAN双水相萃取光度法测定镍(Ⅱ)[J]. journal6, 2015, 36(1): 57-60.
[4]	顾仁勇, 银永忠. 超临界CO₂萃取栝楼籽油工艺条件优化[J]. journal6, 2012, 33(2): 99-102.
[5]	彭清忠, 石进校, 易浪波, 彭清静. 超临界CO₂流体萃取南方红豆杉针叶中的紫杉醇[J]. journal6, 2009, 30(5): 93-95.
[6]	易浪波, 彭清忠, 田向荣, 杨骁慧, 彭清静. 光萼小蜡花精油的超临界CO₂萃取及其GC-MS分析[J]. journal6, 2007, 28(1): 98-101.
[7]	梁亮, 蔡石坚, 伍艳, 邹海燕, 刘志霄. 紫穗槐槐角精油的超临界CO₂萃取及其成分分析[J]. journal6, 2006, 27(4): 99-102.
[8]	张世文, 姚祖凤. 萃取-结晶法制备高纯辣椒碱类化合物[J]. journal6, 2002, 23(2): 90-92.
[9]	张欣, 张平, 蔡水洪, 刘洪来. 预分散溶剂萃取及其在生物产品分离中的应用[J]. journal6, 2001, 22(2): 64-66.
[10]	李辉, 尹笃林. 香兰素合成技术研究进展[J]. journal6, 2001, 22(1): 90-93.