气固并流上行流动中颗粒均匀分布的稳定性

journal6 ›› 2006, Vol. 27 ›› Issue (1): 63-70.

气固并流上行流动中颗粒均匀分布的稳定性

(1.湖南大学工程力学系,湖南长沙 410082;2.清华大学工程力学系,北京 100084)

出版日期:2006-01-25 发布日期:2012-09-16

Stability Analysis on Particle Uniform Distribution in Cocurrent-up Gas-Solid Flow

(1.Department of Engineering Mechanics,Hunan University,Changsha 410082,China；2.Department of Engineering Mechanics,Tsinghua University,Beijing 100084,China)

Online:2006-01-25 Published:2012-09-16
About author:LIU Chun-rong（1972-）,male,was born in Kunming City,Yunnan Province;lecturer of Department of Engineering Mechanics,Hunan University,PhD;research areas are experimental fluid mechanics,multiphase flow,particle image velocimetry (PIV) and particle tracking velocimetry(PTV).
Supported by:
The National Natural Science Foundation of China(50376028)

摘要/Abstract

摘要：对气固并流上行流动中颗粒均匀分布的稳定性进行了分析.以颗粒运动学理论为基础,推导了偏离颗粒均匀分布状态的小扰动方程,并给出在扰动波长和颗粒体积分数为参数的空间上系统稳定的范围.由此发现，在颗粒浓度不太高的情况下，系统对于短波扰动是稳定的，对于长波扰动则是不稳定的.在表观气速较高的情况下，颗粒均匀分布状态几乎对所有扰动波都是不稳定的.当颗粒浓度很低时，只有波长很大的扰动才会使系统失稳，颗粒在某种程度上能保持均匀分布状态.当颗粒粒径小于某一临界值时，随颗粒粒径的增大，颗粒能保持均匀分布的浓度范围将减小；当颗粒粒径大于某一临界值时，随颗粒粒径的增大，颗粒能保持均匀分布的浓度范围将增大.物质密度较低的颗粒能在较大的颗粒浓度范围内保持均匀分布状态.

关键词： 稳定性分析, 气固两相流动, 颗粒运动学, 颗粒分布

Abstract: The stability of particle uniform distribution in concurrent-up gas-solid flow is analyzed in this paper.The equations of small disturbances departing from the uniformity are derived on the basis of the particle kinetic theory.The stability ranges of the system on the parameters space of disturbance wavelength and the particle volume fraction are presented.It is found that the system is stable for the disturbances with very short wavelength and unstable for disturbances with longer wavelength unless the particle phase is very dense.The situation of particle uniform distribution can hardly be stable for all disturbances in the case of higher superficial gas velocity.When the particle phase is very dilute,only the disturbances with very long wavelength can drive the system unstable,the distribution of particles can remain uniformity to some extent.As the particle diameter increases,the range of particle concentration in which particle can distribute uniformly becomes narrower when the particle diameter is less than a critical value,while it will become wider when the particle diameter is larger.The particles with small density can distribute uniformly in a wider range of particle concentration.

Key words: stability analysis, gas-solid flows, particle kinetic theory, particle distribution

. 气固并流上行流动中颗粒均匀分布的稳定性[J]. journal6, 2006, 27(1): 63-70.

参考文献

[1] ARASTOOPOUR H.Numerical Simulation and Experimental Analysis of Gas-Solid Flow Systems:1999 Fluor-Daniel Plenary Lecture [J].Powder Technology,2001,119:59-67.

[2] BI H T,GRACE J R.Flow Regime Diagrams for Gas-Solid Fluidization and Upward Transport [J].International Journal of Multiphase Flow,1995,21(6):1 229-1 236.

[3] BI H T,ELLIS N,ABBA I A，et al.A State-of-the-Art Review of Gas-Solid Turbulent Fluidization [J].Chemical Engineering Science,2000,55:4 789-4 825.

[4] SMOLDERS K,BAEYENS J.Gas Fluidized Beds Operating at High Velocities:A Critical Review of Occurring Regimes [J].Powder Technology,2001,119:269-291.

[5] LI J,KWAUK M.Particle-Fluid Two-Phase Flow:The Energy-Minimization Multi-Scale Method [M].Beijing:Metallurgical Industry Press,1994.

[6] TANAKA T,TSUJI Y.Numerical Simulation of Gas-Solid Two-Phase Flow in a Vertical Pipe:On the Effect of Interparticle Collision [J].ASME FED Gas-Solid Flows,1991,121:123-128.

[7] ZHOU H,FLAMANT G,GAUTHIER D,et al.Lagrangian Approach for Simulating the Gas-Particle Flow Structure in a Circulating Fluidized Bed Riser [J].International Journal of Multiphase Flow,2002,28:1 801-1 821.

[8] LIU M,ZHANG H Q,WANG X L,et al.Numerical Simulation of Cluster Formation in Dense Gas-Solid Flow [J].Journal of Combustion Science and Technology,2003,9(2):128-134.

[9] YONEMURA S,TANAKA T,TSUJI Y.Cluster Formation in Gas-Solid Flow Predicted by the DSMC Method [J].ASME FED Gas-Solid Flows,1993,166:303-309.

[10] WASSEN E,FRANK T.Simulation of Cluster Formation in Gas-Solid Flow Induced by Particle-Particle Collisions [J].International Journal of Multiphase Flow,2001,27:437-458.

[11] MURRAY J D.On Mathematics of Fluidization-1 [J].Journal of Fluid Mechanics，1965,21:465-501.

[12] GARG S K,PRITCHETT J W.Dynamics of Gas-Fluidized Beds [J].Journal of Applied Physics,1975,46(10):4 493-4 500.

[13] BATCHELOR G K.A New Theory of the Instability of a Uniform Fluidized Bed [J].Journal of Fluid Mechanics,1988,193:75-110.

[14] GIDASPOW D.Multiphase Flow and Fluidization:Continuum and Kinetic Theory Descriptions [M].New York:Academic Press,1994.

[15] WEN C Y,YU Y H.Mechanics of Fluidiztion[J].Chemical Engineering Progress Symposium,1966,Series 62:100-111.

[16] KOCH D L.Kinetic Theory for a Mono-Disperse Gas-Solids Suspension [J].Physics Fluids,1990,A2:1 711-1 723.