超滤膜间歇处理处理含油废水的实验效果

journal6 ›› 2005, Vol. 26 ›› Issue (4): 21-25.

超滤膜间歇处理处理含油废水的实验效果

(中南大学冶金科学与工程学院，湖南长沙 410083)

出版日期:2005-10-15 发布日期:2012-09-17

Research on Treatment Effect Under Intermittent Cross-Flow of Oil Wastewater by Ultrafiltration Membrane

(College of Metallurgical Science and Engineering,Central South University,Changsha 410083,Hunan China)

Online:2005-10-15 Published:2012-09-17
About author:HE De-wen(1968-),Male,was born in Hunan Yongzhou,associate professor,post-doctor in Central South University,majoring in solid waste pollution control and reutilization.
Supported by:
Supported by the National Science Foundation of China (50308011)

摘要/Abstract

摘要：本实验采用不同截留分子量的聚乙烯超滤膜在间歇式操作条件下处理含油液废水，实验考查了压力、温度对透水率和CODCr去除率的影响.结果表明：在间歇式操作条件下超滤膜处理乳化液废水的透水率受操作压力和温度的影响，对于截留分子量为8 000的超滤膜应选择0.3～0.7　MPa的操作压力，而对于截留分子量为2　500的超滤膜选择0.7～1.0　MPa的压力，同时，超滤膜的温度范围选择为25～32　℃，采用截留分子量为2　500的聚乙烯超滤膜间歇含油废水CODCr去除率可达93%左右.

关键词： 含油废水, 超滤膜, 间歇操作, 渗透水, CODCr

Abstract: Polyethylene glycol membranes with different molecular weight cut-offs under intermittent cross-flow condition are used to treat oil wastewater,and their experimental conditions including pressure,temperature on permeate rate and removal rate of chemical oxygen demand (CODCr) are studied in the paper.The results show the permeate rate of ultrafiltration membrane can be influenced by pressure and temperature,and pressure is chosen between 0.3～0.7　MPa to the PEG with molecular weight cut-offs of 8　000 and between 0.7～1.0 MPa to the PEG with molecular weight cut-offs of 2　500,and temperature is chosen between 25～32　℃.The UF membrane under intermittent cross-flow operating mode can remove up to 93% COD.

Key words: oil wastewater, ultrafiltration membrane, intermittent cross-flow, permeate water, CODcr

何德文. 超滤膜间歇处理处理含油废水的实验效果[J]. journal6, 2005, 26(4): 21-25.

HE De-Wen. Research on Treatment Effect Under Intermittent Cross-Flow of Oil Wastewater by Ultrafiltration Membrane[J]. journal6, 2005, 26(4): 21-25.

参考文献

[1] SHENG H Lin,WEN J Lan.Treatment of Waste Oil/Water Emulsion by Ultrafiltration and Ion Exchange [J].Water Reseach,1998,32(9):2 680-2 688.

[2] LU Shanzhong,QIAN Kunmin.New Method to Treat Waste Emulsion [J]Water & Waste Water Engineering,2000,26(7):39-45.

[3] LU Bin,LU Xiaoqian.Engineering Application of Treating Technology of Oily Emulsified Wastewater [J].Environmental Engineering,2001,19(3):12-15.

[4] SHOICHI KUNIKANE,YASUMOTO MAGARA,MASAKI ITOH，et al.A Comparative Study on the Application of Membrane Technology to the Public Water Supply [J].Journal of Membrane Science,1995,102:149-154.

[5] WIESNER M R,CHELAM S.The Promise of the Membrane Technology,Environ [J].Sci. Technol,1999,33(17):360-366.

[6] MARIA M CORTALEZZI,JEROME ROSE,GEORGE F WELLS,et al.Ceramic Membranes Derived From Ferroxane Nanoparticles: a New Route for the Fabrication of Iron Oxide Ultrafiltration Membranes [J].Journal of Membrane Science,2003,227:207-217.

[7] BANSAL I K.Concentration of Oily and Latex Wastewater Using Ultrafiltration Inorganic Membranes [J].Ind. Water Engineering,1976,13(10):6-15.

[8] BODZEK M,KONIECZNG K.The Use of Ultrafiltration Membranes Made of Various Polymers in the Treatment of Oil-Emulsion Wastewaters [J].Waste Management,1992,12:75-86.

[9] LIN S H,LAN W J.Waste Oil/Water Emulsion Treatment by Membrane Processes [J].Journal of Hazardous Materials,1998,59:189-199.

[10] ZHANG Guojun,LIU Zhongzhou.Development of the Mechanism and the Controlled Technique of Ultrafiltration Membrane Fouling [J].Membrane Science and Technology,2001,21(4):39-46.

[11] KIM K J,FANE A G,FELL C J D，et al.Fouling Mechanisms of Membranes During Protein Ultrafiltration [J].Journal of Membrane Science,1992,68(1):79-91.

[12] TANIA H.RIBEIRO,JORGE RUBIO,ROSS W.SMITH.A Dried Hydrophobic Acquaphyte as an Oil Filter for Oil/Water Emulsions [J].Spill Science & Technology Bulletin,2003,8(5):483-489.

[13] WANG Xiaochang,WANG Jin.Kinetic Study of Membrane Fouling Under Cross-Flow Ultrafiltration Opteration [J].Environmental Chemisty,2002,21(6):552-558.

[14] CROZES G F,JACANGELO J G,ANSELME C,et al.Impact of Ultrafiltration Operation Conditions on Membrane Irreversible Fouling [J].Journal of Membrane Science,1997,124(1):63-76.

[15] WU Guangxia,ZHANG Donghua,QIAN Yanjun.The Fouling and Cleaning of Ultrafiltration Membrane Module [J].Environmental Chemisty(in Chinese),2002,21(4):389-342.