燃烧法制备LiFePO4及其燃烧机制

doi:10.3969/j.cnki.jdxb.2015.06.013

journal6 ›› 2015, Vol. 36 ›› Issue (6): 53-58.DOI: 10.3969/j.cnki.jdxb.2015.06.013

燃烧法制备LiFePO₄及其燃烧机制

陈娟，石月，孙念，陈常连，王树林，黄志良

（武汉工程大学材料科学与工程学院，湖北武汉430074）

出版日期:2015-11-25 发布日期:2015-12-23

Combustion Method to Synthesize LiFePO₄ and Combustion Mechanism

CHEN Juan, SHI Yue, SUN Nian, CHEN Chang-Lian, WANG Shu-Lin, HUANG Zhi-Liang

(School of Materials Science and Engineering,Wuhan Institute of Technology,Wuhan 430074,China)

Online:2015-11-25 Published:2015-12-23
About author:CHEN Juan(1992—),female,was born in Gong’an County,Hubei Province,graduate student for master degree;research area is function materials
Supported by:
National Natural Science Foundation of China (51374155);National Key Technology R&D Program (2013BAB07B01);Hubei Province Key Technology R&D Program (2014BCB034);National Natural Science Foundation of Hubei Province of China (2014CFB796)

摘要/Abstract

摘要：许多合成磷酸铁锂(LFP)的传统方法具有反应时间长或者Fe²⁺易氧化的缺点.使用硫酸亚铁、磷酸氢二铵和硝酸锂为主要原料，通过燃烧法制备LFP，由XRD和TG-DSC表征所得样品.结果表明，该燃烧法可以在600 ℃短时间内合成较纯的LFP，并且不需要通入保护气体.对燃烧机制的研究表明，从120~290 ℃，干凝胶的燃烧导致有机柠檬酸的自蔓延燃烧反应，同时引入的碳防止Fe²⁺的氧化，并且当φ=n(CA)/n(LFP)=2时，是合成LFP材料柠檬酸的最佳用量.

关键词： 燃烧法, 制备, LiFePO₄, 电池

Abstract: Many traditional methods used to synthesize LiFePO₄ (LFP for short) have the disadvantages of long reaction time or unavoidable oxidation of Fe²⁺.In this work,the combustion method was developed to facilely synthesize LFP by using ferrous sulfate,diammonium hydrogen phosphate and lithium nitrate as main raw materials.The synthesized LFP was characterized by XRD and TG-DSC.The results showed that the combustion method could facilely synthesize purer LFP at 600 ℃ in a short period without the protection of inert gas.The studies on combustion mechanism indicated that from 120 ℃ to 290 ℃ the organic citric acid in the dry gel was combusted which could lead to a self-propagating combustion reaction and bring in carbon preventing the oxidation of Fe²⁺ simultaneously.And φ=n(CA)/n(LFP)=2 is the best amount of citric acid to synthesize LFP materials.

Key words: combustion method, synthesize, LiFePO₄, battery

陈娟, 石月, 孙念, 陈常连, 王树林, 黄志良. 燃烧法制备LiFePO₄及其燃烧机制[J]. journal6, 2015, 36(6): 53-58.

CHEN Juan, SHI Yue, SUN Nian, CHEN Chang-Lian, WANG Shu-Lin, HUANG Zhi-Liang. Combustion Method to Synthesize LiFePO₄ and Combustion Mechanism[J]. journal6, 2015, 36(6): 53-58.

参考文献

[1] XI Anjing.Lithium Iron Phosphate Electrochemical Impedance Spectroscopy Experimental Study[D].Beijing:Tsinghua University,2012.

[2] HAN Cong,SHEN Xiangqian,ZHOU Jianxin.Preparation of LiFePO4/Ni Composite Microspheres[J].J. Chin. Ceram. Soc.,2008,36(4):559-564.

[3] TANG Zhiyuan,QIU Ruiling,TENG Guopeng,et al.Research Progress of LiFePO4 Cathode Material for Lithium Ion Batteries[J].Chem. Ind. Eng. Prog.,2008,27(7):995-1 000.

[4] CAO Yanbing,HU Guorong,DU Ke,et al.Synthesis of LiFePO4 Cathode Materials by Polyol Reduction Processing[J].Chinese Journal Inorganic Chemistry,2010,26(6):1 061-1 065.

[5] SANG Junli,WANG Qiaojuan,GUO Xifeng.Synthesis and Characterization Technique of LiFePO4 Cathode Material[J].Inorganic Chemicals Industry,2008,40(2):13-16.

[6] PADHI A K,GOODENOUGH J B,NANJUNDASWAMY K S.Phospho-Olivines as Positive-Electrode Materials for Rechargeable Lithium Batteries[J].Journal of the Electrochemical Society,1997,144(4):1 188-1 194.

[7] SCROCE F,EPIFANIO A D,HASSOUN J,et al.A Novel Concept for the Synthesis of Anim-Proved LiFePO4 Lithium Battery Cathode[J].Electrochem Solid-State Letter,2002,5(3):47-50.

[8] WANG Xiaojian,REN Junxia,LI Yuzhan,et al.Synthesis of Cathode Material “Carbon-Included” LiFePO4 by Microwave Heating[J].Chinese J. Inorg. Chem.,2005,21(2):249-252.

[9] PROSINI P P,CAREWSKA M,SCACCIA S,et al.A New Synthesis Route for Preparing LiFePO4 with Enhanced Electrochemical Performance[J].Journal of the Electrochemical Society,2002,149(7):886-890.

[10] ZHANG Peixin,WEN Yanxuan,LI Jianhong,et al.Performance and Structure of Mg2+ Doped Lithium Iron Phosphate Prepared by Chemical Precipitation Methode[J].Chin. J. Funct. Mater.,2006,37(12):1 942-1 945.

[11] XIE Hui,ZHOU Zhentao.Synthesis and Electrochemical Performances of LiFePO4/C Composites by Solid State Reduction Method[J].Journal of Inorganic Materials,2007,22(4):631-636.

[12] LI Wenxia,YIN Sheng.Low Temperature Combustion Synthesis of Ultrafine Ceramic Powder[J].J. Chin. Ceram. Soc.,1999,27(1):71-78.

[13] LI Wenxia,YIN Sheng.Organic Materials in Combustion Synthesis[J].Materials Review,2000,14(5):45-48.

[14] WANG Xinyu,PIAN Yingchao,LI Shipu,et al.Exploration of Mechanism for Nanosized Hydroxyapatite Powders Prepared by Auto-Combustion Method and Influencing Factors[J].Journal of the Chinese Ceramic Society,2002,30(5):564-568.

[15] YAMADA A,HOSOYA M,CHUNG SAI-CHEONG,et a1.Olivine-Type Cathodes:Achievements and Problems[J].J. Power Sources.,2003,119-121:232-238.

燃烧法制备LiFePO₄及其燃烧机制

Combustion Method to Synthesize LiFePO₄ and Combustion Mechanism

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨平, 刘思佳, 万超意, 刘家乐, 曹静, 蒋剑波. MnO₂/CNTs复合物的合成及其AZIBs正极材料性能[J]. 吉首大学学报（自然科学版）, 2023, 44(1): 34-43.
[2]	龙芮涞, 吴显明, 吴秀婷, 尹偲硕. Li₄Ti₅O₁₂材料的固相法制备及其煅烧温度[J]. 吉首大学学报（自然科学版）, 2022, 43(3): 72-78.
[3]	蒋梓浩, 任涛, 周祺, 骆加冕. 基于随机森林与L-M算法的C4烯烃制备优化模型[J]. 吉首大学学报（自然科学版）, 2022, 43(3): 79-83.
[4]	靳博暄, 马凯璇, 张宇, 张若晨, 王岭, 何章兴. 可充电水系锌离子电池无机非金属涂层研究进展[J]. 吉首大学学报（自然科学版）, 2021, 42(4): 66-74.
[5]	刘赛求, 江友良, 邹秋玲, 马渤然, 向延鸿, 伍建华, 熊利芝, 吴贤文. 以乙炔黑为碳源制备Li₃V₂(PO₄)₃/C复合材料[J]. 吉首大学学报（自然科学版）, 2021, 42(3): 73-78.
[6]	刘璐，姜臻，刘娜，何章兴. 水系负极材料磷酸钛锂的研究进展[J]. 吉首大学学报（自然科学版）, 2019, 40(2): 55-59.
[7]	陈美艳，杨庆，吴贤文，邹莉，姚正西，李方宁. CoMoO₄水热法制备及其在锂/钠离子电池中的应用[J]. 吉首大学学报（自然科学版）, 2019, 40(1): 72-77.
[8]	李文昭,黄志良,鲁冕,陈常连,张占辉. 燃烧法制备磷灰石型碱土掺杂硅酸镧电解质[J]. 吉首大学学报（自然科学版）, 2017, 38(1): 63-69.
[9]	贺潜，郑杰，田云刚，刘一涵，王建霞，魏华. 生漆中C₁₅三烯漆酚的分离制备[J]. 吉首大学学报（自然科学版）, 2016, 37(5): 42-44.
[10]	王斌，黎璐，蒋崇文，钟宏. 钛掺杂有序介孔硅Ti-KIT-6的制备与表征[J]. 吉首大学学报（自然科学版）, 2016, 37(4): 49-56.
[11]	张文泽，王玉娥，吴贤文，罗飞，程刚，何章兴. 全钒液流电池电极材料的研究进展[J]. 吉首大学学报（自然科学版）, 2016, 37(4): 61-66.
[12]	滕瑶, 王亚光, 费讲驰, 鲁涛, 何则强. 底物对微生物燃料电池产电性能的影响[J]. journal6, 2015, 36(3): 77-81.
[13]	刘芸双, 傅伟昌. 硝酸银硅胶柱梯度洗脱法纯化桐酸甲酯[J]. journal6, 2015, 36(1): 52-56.
[14]	何章兴, 贺尧毅, 陈辰, 杨帅, 陈文聪, 刘素琴, 何震. 三乙醇胺对全钒液流电池正极电解液的影响[J]. journal6, 2013, 34(3): 62-65.
[15]	麦发任, 吴显明, 赵俊海, 刘金练, 曾姝. 尖晶石型Li₄Ti₅O₁₂的合成及其性能[J]. journal6, 2012, 33(5): 98-101.